Toyota MR2 since 1991, service e-manual - Скачать книгу бесплатно

Content Introduction How to use this manual Identification information General repair instructions Precautions for vehicles equipped with srs airbag Precautions for vehicles equipped with a catalytic converter Precautions for vehicles with an audio system with built-in anti-theft system Vehicle lift and support locations Abbreviations used in this manual Maintenance Maintenance schedule Maintenance operations General maintenance Engine mechanical Description Troubleshooting Engine tune-up Toyota-variable induction system Compression check Timing belt Cylinder head Cylinder block Exhaust system Exhaust pipes and heat insulators Turbocharger system Description Precautions Troubleshooting turbocharger Intercooler Emission control systems System purpose Component layout and schematic drawing Positive crankcase ventilation (PCV) system Fuel evaporative emission control (EVAP) system Exhaust gas recirculation (egr) system Three-way catalyst (TWC) system EFI system Description Precautions Inspection precautions Troubleshooting Diagnosis system Fuel system Air induction system Electronic control system Cooling system Description Troubleshooting Engine coolant check Replacement of engine of coolant Water pump Thermostat Radiator Electric cooling fans Lubrication system Description Troubleshooting Oil pressure check Replacement of engine oil and oil filter Oil pump Oil cooler Oil nozzles Ignition system Precautions Troubleshooting Ignition system circuit On-vehicle inspection Distributor Starting system Troubleshooting Starter Starter relay Clutch starter switch Charging system Precautions Troubleshooting On-vehicle inspection Alternator Ignition main relay Clutch Troubleshooting Check and adjustment of clutch pedal Bleeding of clutch system Inspection of clutch start system Clutch master cylinder Clutch release cylinder Clutch unit Manual transaxle Description Precautions Troubleshooting Removal and installation of transaxle Installation of component parts Shift lever and control cable Automatic transaxle Description Precautions Troubleshooting On-vehicle repair Removal and installation of transaxle Torque converter Removal of component parts Installation of component parts Shift lock system Suspension and axle Troubleshooting Wheel alignment Front axle hub Front suspension Rear axle shaft and carrier Rear drive shaft Rear suspension Brake system Precautions Troubleshooting Checks and adjustments Master cylinder Brake booster Front brake Rear brake Proportioning and by-pass valve Anti-lock brake system Steering Precautions Troubleshooting On-vehicle inspection Steering column Manual steering gear housing Power steering SRS airbag General description Description Operation Inspection items and replacement requirements Removal and installation of component parts replacement of repair wire for front airbag sensor Troubleshooting Disposal of steering wheel pad (with airbag) Disposal of center airbag sensor assembly Body electrical system General information Power source Ignition switch Lighting system Wiper and washer system Combination meter Defogger system Power window control system Power door lock control system Power mirror control system Cruise control system Theft deterrent system Audio Clock Body General information Hood Headlight Front door Luggage compartment door moulding Windshield Quarter window glass Back window glass T-bar roof Moon roof Instrument panel Seat Seat belts Body dimensions Air conditioning system General information Description Preparation Troubleshooting Refrigeration system Drive belt Refrigeration lines Compressor Receiver Condenser Cooling unit Evaporator Expansion valve Thermistor A/C control assembly Pressure switch Water temperature sensor Servomotors Blower motor Condenser fan motor Blower resistor Heater main relay Magnetic clutch relay Fan main relay Fan relay Vacuum hose circuit Vacuum switching valve (VSV) A/C amplifier Service specifications Standard bolt torque specifications SST and SSM Electrical wiring diagrams